What is an MCOR?
The MCOR (Motor Controller Output Regulator) is the unit which controls the solenoid/controller activation, using an internal microswitch. It also controls the throttle input command using an electronic rheostat circuit board.
Does your Club Car Precedent IQ or DS IQ go into a "limp" mode?
Do you find intial movement fine, then goes slow? It may be your Speed Sensor.
To conduct simple Speed Sensor test;
Before proceeding, you must have a functioning Reverse Buzzer.
You can easily verify this but putting the Forward and Reverse Switch into the Reverse position and listen for the audible tone.
You also need to make sure you are in a safe environment to conduct driven/loaded testing if required.
To put into diagnostic mode;
Tyre Pressure & Condition
Tyre Pressure
WARNING! Over inflation can result in injury &/or damages. Never over inflate past manufacture specs.
Standard golf cart tyre size is 18x8.5-8 and most have max 22PSI inflation.
We recommended tyre pressure to be between 18-20PSI.
All four tyres should have the same tyre pressure.
Tyre pressures should also be checked every three to four weeks.
Battery Care & Maintenance
Lead Acid – Wet Filled
WARNING! You must wear PPE, including eye protection.
General Cleaning Instructions:
- Check that all vent caps are tightly in place.
- Clean the battery top with a cloth and/or brush and a solution of baking soda and water.
- When cleaning, do not allow any cleaning solution or other foreign matter to get inside the battery.
- Clean battery terminals/posts and the battery cable lugs using baking soda and water solution and/or with wire brush.
- Rinse with water and allow to dry.
- Reconnect the battery cables to the battery terminals and thinly coat them with an anti-corrosive spray (battery terminal protectant).
- Keep the area around batteries clean and dry.
